Experimental Study on Reinforced Geogrid of Construction and Demolition Wastes Based on DIC Technology

Authors

TAN Peng, China Road & Bridge Corporation , Beijing 100011 , ChinaFollow
LI Hai, School of Traffic & Transportation Engineering , Changsha University of Science & Technology , Changsha , Hunan 410114 , China
LI Xiangping, School of Traffic & Transportation Engineering , Changsha University of Science & Technology , Changsha , Hunan 410114 , China
GU Fan, School of Traffic & Transportation Engineering , Changsha University of Science & Technology , Changsha , Hunan 410114 , ChinaFollow
ZHANG Junhui, School of Traffic & Transportation Engineering , Changsha University of Science & Technology , Changsha , Hunan 410114 , China

Corresponding Author

顾凡，男，博士，教授.E-mail：fan.gu@csust.edu.cn

Abstract

In order to control differential settlement caused by new and old subgrade connections after expressway reconstruction and expansion，this paper proposed a layered treatment structure for the loose steps of the old road with high water content.A layer of construction and demolition waste was laid on the step surface of the old road to wrap the geogrid.The treatment effect was compared with that of sand wrapping and lime mixing，and the digital speckle correlation （DIC） was used to observe the reinforced influence zone，so as to determine the thickness of different layers of the subgrade wrapped by construction and demolition wastes.The particle rotation and displacement were further analyzed，and the reliability and accuracy of the reinforced influence zone determined by DIC observation were verified.The test results show that：① Among the measures to improve the interface strength of reinforced soil in the old road steps，the effect from good to bad is construction and demolition wastes C （particle size of 10‒20 mm） > construction and demolition wastes B （particle size of 5‒10 mm） > sand > construction and demolition wastes A （particle size of 1‒5 mm） > mixed ash of 6% > mixed ash of 4%，and the reinforcement effect increases with the increase in the particle size of the construction and demolition wastes；② The DIC test results show that the area of the reinforced influence zone decreases with the increase in normal stress，and its thickness above the geogrid is greater than t hat below the geogrid.The particles that rotate are mainly concentrated within 3 cm below the geogrid and 5 cm above the geogrid；③ The recommended thickness of the layer wrapped by construction and demolition wastes is determined based on the thickness of the reinforced influence zone：about 20 cm in the middle of the subgrade，about 15 cm in the bottom of the subgrade，and not less than 25 cm in the upper part of the subgrade.

Publication Date

7-30-2024

DOI

10.14048/j.issn.1671-2579.2024.04.001

First Page

1

Last Page

10

Submission Date

February 2025

Recommended Citation

Peng, TAN; Hai, LI; Xiangping, LI; Fan, GU; and Junhui, ZHANG (2024) "Experimental Study on Reinforced Geogrid of Construction and Demolition Wastes Based on DIC Technology," Journal of China & Foreign Highway: Vol. 44: Iss. 4, Article 1.
DOI: 10.14048/j.issn.1671-2579.2024.04.001
Available at: https://zwgl1980.csust.edu.cn/journal/vol44/iss4/1

Reference

[1]刘志明 .沈大高速公路改扩建工程技术论文集 [M].北京 :人民交通出版社 ,2005 .LIU Zhiming .Collection of technical papers on reconstruction and expansion project of Shenyang-Dalian Expressway [M].Beijing :China Communications Press ,2005 .
[2]焦文慧，王凤池，张萌杰 .废弃轮胎土工格室加筋路堤承载特性分析 [J/OL ].中外公路 ，1-10[2024 -05-25].http://kns.cnki.net/kcms/detail/ 43.1363 .U.20240325 .1110 .002.html .JIAO Wenhui ，WANG Fengchi ，ZHANG Mengjie .Analysis of bearing characteristics of waste tire geocell reinforced embankment [J/OL ].Journal of China & Foreign Highway ,1-10[2024 -05-25].http://kns .cnki.net/kcms/detail/43.1363 .U.20240325 .1110 .002.html .
[3]张锐 ,龙明旭 ,郑健龙 ,等.土工格栅与膨胀土相互作用研究进展及思考 [J].中外公路 ,2020 ,40(增刊 2):13-20.ZHANG Rui ,LONG Mingxu ,ZHENG Jianlong ,et al .Research progress and thinking on interaction between geogrid and expansive soil [J].Journal of China & Foreign Highway ,2020 ,40(sup 2):13-20.
[4]田林 ,李宁 ,王宇 ,等.土工格室形式与填料类型对公路地基承载力的影响 [J].中外公路 ,2022 ,42(2):15-23.TIAN Lin ,LI Ning ,WANG Yu ,et al .Influence on the type of geocell and filler on bearing capacity for highway road subgrade [J].Journal of China & Foreign Highway ,2022 ,42(2):15-23.
[5]冯晓静 ,杨庆 ,李首龙 ,等.含水量对红黏土中土工格栅拉拔性能影响的试验研究 [J].岩石力学与工程学报 ,2009 ,28(增刊 2):4059 -4064 .FENG Xiaojing ,YANG Qing ,LI Shoulong ,et al .Experimental study on the influence of water content on the drawing performance of geogrids in red clay [J].Chinese Journal of Rock Mechanics and Engineering ,2009 ,28(sup 2):4059 -4064 .
[6]陈榕 ,王喜强 ,郝冬雪 ,等.季节性冻土中土工格栅加筋特性试验研究 [J].岩土工程学报 ,2019 ,41(6):1101 -1107 .CHEN Rong ,WANG Xiqiang ,HAO Dongxue ,et al .Experimental investigation on reinforced characteristics of geogrids in seasonal frozen soil [J].Chinese Journal of Geotechnical Engineering ,2019 ,41(6):1101 -1107 .
[7]PANT A ,RAMANA G V ,DATTA M ,et al.Coal combustion residue as structural fill material for reinforced soil structures [J].Journal of Cleaner Production ,2019 ,232:417-426.
[8]ABDI M R ,ZANDIEH A R .Experimental and numerical analysis of large scale pull out tests conducted on clays reinforced with geogrids encapsulated with coarse material[J].Geotextiles and Geomembranes ,2014 ,42(5):494-504.
[9]崔新壮 ,楼俊杰 ,王磊 ,等.利用单一级配碎石材料的高强土 工 格 栅 ‒土 界 面 强 化 方 法 :中 国，CN103628379 B[P].2015 -07-29.CUI Xinzhuang ,LOU Junjie ,WANG Lei ,et al .Method for reinforcing interface of high-intensity geogrid and soil through single graded crushed stone material :China ,CN103628379 B[P].2015 -07-29.
[10]饶钰琳 .筋材 ‒砂土 ‒黏土层状加筋结构双轴 、直剪、拉拔试验离散元分析 [D].武汉 :华中科技大学 ,2019 .RAO Yulin .Discrete element analysis of biaxial ,direct shear and pulling tests of geogrid-sand-clay layered reinforced structure [D].Wuhan :Huazhong University of Science and Technology ,2019 .
[11]张嘎 ,张建民 .土与土工织物接触面力学特性的试验研究[J].岩土力学 ,2006 ,27(1):51-55.ZHANG Ga ,ZHANG Jianmin .Experimental study on behavior of interface between soil and geotextile [J].Rock and Soil Mechanics ,2006 ,27(1):51-55.
[12]胡幼常 ,靳少卫 ,宋亮 ,等.基于影响带观测的加筋土坡稳定性分析 [J].岩土工程学报 ,2017 ,39(2):228-234.HU Youchang ,JIN Shaowei ,SONG Liang ,et al .Stability analysis of reinforced soil slopes based on observation of reinforcement-effected strip [J].Chinese Journal of Geotechnical Engineering ,2017 ,39(2):228-234.
[13]聂如松 ,谭永长 ,郭一鹏 ,等.风积沙 ‒土工格栅界面摩擦特性拉拔试验研究 [J].铁道科学与工程学报 ,2022 ,19(11):3235 -3245 .NIE Rusong ,TAN Yongchang ,GUO Yipeng ,et al .Pullout test study of frictional resistance characteristics of geogrids and aeolian sand interface [J].Journal of Railway Science and Engineering ,2022 ,19(11):3235 -3245 .
[14]王军 ,胡惠丽 ,刘飞禹 ,等.粒孔比对筋土界面直剪特性的影响 [J].岩土力学 ,2018 ,39(增刊 2):115-122.WANG Jun ,HU Huili ,LIU Feiyu ,et al .Effect of particle-hole ratio on direct shear characteristics of reinforced soil interface [J].Rock and Soil Mechanics ,2018 ,39(sup 2):115-122.
[15]包承纲 .土工合成材料界面特性的研究和试验验证 [J].岩石力学与工程学报 ,2006 ,25(9):1735 -1744 .BAO Chenggang .Study on interface behavior of geosynthetics and soil [J].Chinese Journal of Rock Mechanics and Engineering ,2006 ,25(9):1735 -1744 ..
[16]丁金华 ,包承纲 ,丁红顺 .土工格栅与膨胀岩界面相互作用的拉拔试验研究 [C]// 第二届全国岩土与工程学术大会论文集 (下册 ).武汉 ,2006 :452-459.DING Jinhua ,BAO Chenggang ,DING Hongshun .Pull out test study on interaction between geogrid and expansive rock interface [C]//Proceedings of the Second National Geotechnical and Engineering Academic Conference (Volume Ⅱ),Wuhan ,2006 :452-459.
[17]王家全 ,祁航翔 ,林志南 ,等.基于数字图像分析的土工合成材料加筋砂土拉拔试验研究 [J].岩土力学 ,2022 ,43(12):3259 -3269 .WANG Jiaquan ,QI Hangxiang ,LIN Zhinan ,et al .Pull-out test on geosynthetic reinforced sand based on digital image analysis [J].Rock and Soil Mechanics ,2022 ,43(12):3259 -3269 .